INSTALLATION INSTRUCTIONSAND OWNER'S MANUALUNVENTED GAS FIREPLACEMODELSVFL20IN3(0,1,2,3)10(N,P)-1VFL20IN3(0,1,2,3)(N,P)-1VFL20IN7(0,1,2,3)(N,P)-1
27407-5-1010Page 10In planning the installation for the replace, it is necessary to determine where the unit is to be installed and whe
27407-4-1010 Page 11DF20GBLDF20LBLDF20MBLFIREPLACE WITH SURROUND DIMENSIONS34”25”20 1/2”11 1/2”4 19/64”39 15/16”25 1/2”1 3/4”2 1/4”23 13/32”37 3/8”
27407-5-1010Page 12Water vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for ev
27407-4-1010 Page 13The space in the above example is a conned space because the actual BTU/Hr used is more than the maximum BTU/HR the space can su
27407-5-1010Page 14Figure 8The gas pipeline can be brought in through the right or left side of the appliance. The insert has a Flexline with shutoff
27407-4-1010 Page 15GAS SUPPLY (continued)CLEARANCESFINISHED WALLFLAT MANTEL SHELF2”15”11”4”6”8”10”12”13”17”19”21”Figure 118”MINIMUM CLEARANCE TO PERP
27407-5-1010Page 16Combustible MaterialNo greeting cards, stockings or ornamentation of any type should be placed on or attached to the replac
27407-4-1010 Page 17WIRING THE FIREPLACE WARNINGElectrical wiring must be installed by a licensed electri-cian. WARNINGDISCONNECT REMOTE CON
27407-5-1010Page 18DECORATIVE GLASSGLASS MUST NOT BE PLACED ON TOP OF ORNEXT TO BURNER. GLASS TO BE PLACED ONLYTO THE OUTSIDE OF THE FLANGED OPENING.D
27407-4-1010 Page 19A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly
27407-5-1010Page 2SECTION PAGETABLE OF CONTENTSImportant Safety Information ...
27407-5-1010Page 20A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly.
27407-4-1010 Page 21WARNING:may result causing property damage, personal injury o
27407-5-1010Page 22INTERMITTENT PILOT OPERATING INSTRUCTIONSThermostats are not approved on vented decorative appli-ances.Label all wires prior
27407-4-1010 Page 23INTERMITTENT PILOT REMOTE ELECTRONIC IGNITION AND CONTROL SYSTEMTimer/Thermostat RFRemote HandsetG6R-H3TAPPLICATIONGV60 is a batte
27407-5-1010Page 24• Continuing beeps conrm the ignition is in process.• Once pilot ignition is conrmed, there is main gas ow.• After the igni
27407-4-1010 Page 25Notice: The display shows the set temperature every 30 sec-onds.SETTING THE TEMPERATURE• Select either the TEMP MODE
27407-5-1010Page 267. With the MANUAL knob in MAN position a manual pi-lot valve operator and piezo igniter are accessible. Ignition with
27407-4-1010 Page 27INTERMITTENT PILOT WIRING DIAGRAMMAGRMOSWPANELSWTCSPARKOIButton“RESET”BatteryCompartmentIgnition CableThermocoupleRF AntennaThermo
27407-5-1010Page 28Flames from the pilot (front center of burner) as well as the main ame should be visually checked as the replace is installed.In
27407-4-1010 Page 29Figures 25 and 26 show a correct pilot ame pattern. The correct ame will be blue and will extend beyond the thermocouple. The a
27407-4-1010 Page 3When used without adequate combustion and ventilation air, heater may give off CARBON MONOXIDE, an odorless, poison-ous gas. Do
27407-5-1010Page 30MILLIVOLT PILOTFigure 29INTERMITTENT PILOTFigure 30 service techn
27407-4-1010 Page 31Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation.
27407-5-1010Page 32ga
27407-4-1010 Page 33PARTS LISTIndex No. Part No. DescriptionCOMMON PARTS1 27547 FIREBOX BAFFLE2 27406 BURNER ASSEMBLY COVER3 27082 FIREBOX BOTTOM4 272
27407-5-1010Page 34EXPLODED VIEW123456789101125222324IPI VALVE ASSEMBLY141318192012171615MILIVOLTVALVE ASSEMBLY191512131418171621SETOFFTEMPPM26
27407-4-1010 Page 35Louvers 45 DegGlass Door FrameBottom Cover6x6 Contemporary SurroundContemporary SurroundContemporary ShroudInsert Accessories that
27407-5-1010Page 36SURROUND FRONTSDF20GBL Glass Front34" x 20 1/2" glass panel with mounting brackets, shield and hardware.Glass FrontTrimBo
27407-4-1010 Page 37To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.com. To provid
27407-5-1010Page 38APPLIANCE SERVICE HISTORYDate Dealer Name Service Technician Name Service Performed/Notes
27407-4-1010 Page 39APPLIANCE SERVICE HISTORYDate Dealer Name Service Technician Name Service Performed/Notes
27407-5-1010Page 4Some people cannot smell well. Some people cannot smell the can smell
27407-5-1010Page 40EMPIREEMPIREComfor t SystemsEmpire Comfort Systems Inc.918 Freeburg Ave. Belleville, IL 62220If you have a general question about
27407-4-1010 Page 5For proper burner operation and ame appearance, the ow of primary air into the venturi
27407-5-1010Page 6Notice: During initial ring of this unit, its paint will bake out, and smoke will occur. To prevent triggering of smoke alarms, v
27407-4-1010 Page 7SPECIFICATIONSAccessories for VFL20IN3 (Millivolt) ModelsRemote Control AccessoriesDescriptionFRBC Battery Operated Remote ControlF
27407-5-1010Page 8INSTALLATION IN A FIREPLACE1. Before beginning, check to make sure there is no hidden dam-age to the unit. Take a minute and plan o
27407-4-1010 Page 9FIREPLACE INSERT DIMENSIONSADEBCFGHIJKFigure 1When planning a replace insert installation, it’s necessary to determine:• Gas supp
Commentaires sur ces manuels